KITCHEN TOOLS
6
Juicer SFE 450 A1
Juicer
Operating instructions
KOMPERNASS GMBH
BURGSTRASSE 21 · D-44867 BOCHUM
ID-Nr.: SFE450A1-05/10-V2
INDEX
PAGE
Intended Application
Technical data
2
2
2
2
2
4
4
5
5
6
6
7
7
7
7
8
Items supplied
Operating Elements
Important safety instructions
Assembling and operating the appliance
Preparing the fruits/vegetables
Juicing
Emptying the pulp container and the filter
Disassembly of the juice extractor
Cleaning and Care
Storage
Disposal
Warranty and Service
Importer
Troubleshooting
Read these operating instructions carefully before using the appliance for the first time and preserve this
booklet for later reference. Pass this manual on to whoever might acquire the appliance at a future date.
- 1 -
JUICER
Operating Elements
Stodger
Loading shaft
Housing lid
Clasps
Juice container
Juice outlet
Appliance base
Power cable with plug
On/Off switch (2 speed levels)
Cable rewind
Container (for fruit pulp and vegetable mash)
Filter
q
w
e
r
t
y
u
i
o
a
s
d
f
g
h
Intended Application
The appliance is both intended and suitable for the
juicing of well ripened and peeled fruits and vege-
tables. Only foodstuffs may be processed with the
appliance. Only the original attachments and accesso-
ries, as described herein, may be used. Any other
use or modification is considered improper use and
brings with it the great risk of serious accidents.
The manufacturer declines to accept responsibility
for damage(s) arising out of usage that is contrary
to the instructions specified below. Not for commercial
use.
Drive shaft
Nylon brush (in the stodger on delivery)
separate juice collector with foam separator
(on delivery, packed in the container for pulp
and mash)
Technical data
Mains voltage: 220 - 240 V 50 Hz
~
Rated power:
CO time:
450 W
Important safety instructions
30 Minutes
Protection class: II /
The following safety instructions must always be
adhered to when using electrical appliances:
These instructions will help you avoid severe personal
injuries and/or serious damage(s), and enable you
to achieve better working results.
CO Time
The C.O. Time (Continuous Operation) details how
long an appliance may be used without the motor
overheating and being damaged. After the appliance
has run for this period it must be switched off until
the motor has cooled itself down.
Please read the following information regarding
safety measures and appropriate usage carefully.
Before you begin reading this informaton, please
unfold the page with the illustrations and familiarize
yourself with all functions of the appliance. Carefully
preserve these directions and pass them on, if and
when necessary, to third parties too.
Items supplied
Juicer
Nylon brush (in the stodger)
Operating instructions
- 2 -
• This appliance is not intended for use by individuals
(including children) with restricted physical, physio-
logical or intellectual abilities or deficiences in
experience and/or knowledge unless they are
supervised by a person responsible for their safety
or receive from this person instruction in how the
appliance is to be used. Children should be
supervised to ensure that they do not play with
the appliance.
• To avoid injuries, ensure that all the component
parts are correctly connected and installed.
• Before switching the appliance on, ensure that
the lid has been correctly and firmly closed with
the clamps. If not, the appliance will not start.
Should the clamps become loose during operation,
the appliance stops automatically.
When working with the appliance, NEVER in-
sert your hands or other objects into the loa-
ding shaft. This could lead to grave personal
injuries or serious damage to the appliance.
If pieces of fruit or vegetable cannot be remo-
ved with the stodger, switch the appliance
off, remove the plug from the power socket
and open the appliance.
To avoid potentially fatal electric
shocks:
• The voltage of the power source must match the
details given on the plate affixed to the appliance.
• Arrange for defective power plugs and/or cables
to be replaced at once by qualified technicians
or our Customer Service Department.
• Should the appliance not operate correctly, or
become damaged, arrange for it to be examined
and repaired by Customer Services as soon as
possible.
• Risk of Injury! The cutter is very sharp. Handle
it very carefully.
• DO NOT use the appliance if the rotating sieve
is damaged.
• Do not expose the appliance to rain and never
use it in a humid or wet environment. Take steps
to ensure the power cable never becomes wet
or moist during use.
• Do not touch any rotating parts.
• Turn the appliance off after use and remove the
power plug from the wall socket. Only when the
motor has come to a complete stop may the
appliance be disassembled.
NEVER immerse the appliance base in water
or any other liquid!
NEVER use the appliance:
• if the filter/sieve, power cable or power plug are
damaged,
To avoid the risks of fire or injuries:
• Never leave the appliance unattended whilst in
use.
• Caution! Keep children away from the power
cable and the appliance. Children frequently
underestimate the danger from electrical app-
liances.
•
in the case of malfunctions, or if it has otherwise
been damaged or dropped. Send the appliance
to Customer Services for checking and/or repair.
• The use of attachments and accessories not re-
commended or sold by the manufacturer can
cause fire, electric shocks and/or personal in-
juries.
• Ensure that the appliance stands with a safe and
secure positioning.
• Ensure that the power cable is at all times easily
accessible and that no one can trip over it.
- 3 -
Tips for safety:
• In cases of danger, immediately remove the power
1. Place the juice catchment bowl
on the app-
t
liance base , so that the three tenons and the
u
plug from the wall socket.
juice outlet are securely caught in the recesses.
y
• Use the appliance exclusively for the purposes
described in these operating instructions.
• Always be alert! Always pay attention to what
you are doing and act with common sense. Never
use the appliance when you are distracted or
don’t feel well.
2. Place the filter
on the drive shaft
and press
d
f
it down so that it perceptibly engages. Ensure
that it is firmly seated before continuing with the
assembly.
3. Place the housing lid
on the juice catchment
e
bowl , so that the loading shaft is sitting above
t
• Ensure that the appliance is correctly and com-
pletely assembled before taking it into use. The
appliance can first be taken into use when the
clamps have been closed.
the cutters of the filter
4. Ensure that the housing lid
.
d
is sitting firmly in
e
the recesses of the juice catchment bowl . Lift
t
the clasps
and hook them into the notches on
r
• After every use of the juice extractor ensure that
the On/Off switch is moved to the position "Off"
("0"). . The motor must come to a complete stop
before you begin to disassemble the appliance.
• Remove the power plug from the wall socket
when the appliance is taken out of use, when
removing components and before cleaning it.
• Do not use the appliance outdoors.
the housing lid
5. Press the lower part of the claps
appliance until they engage.
.
e
against the
r
6. Slide the container for fruit pulp and vegetable
mash from below under the ejection shaft.
s
7. Push the foam separator plate in the separate
juice collector and then put the lid on. Place
h
the separate juice collector
ance so that the juice outlet
next to the appli-
projects into the
h
y
juice collector
.
h
Assembling and operating the
appliance
8. Insert the power plug
into the wall socket.
i
•
Select a safe and secure positioning for the
juice extractor. For optimal handling we recom-
mend that the appliance is positioned with the
power cable running from the rear of the app-
liance to the wall socket. All operating elements
can now be directly and easily handled:
Preparing the fruits/vegetables
• Important: Use only well ripened fruit, as other-
wise the filter
could become quickly blocked.
d
This would require repeated cleaning of the filter
.
d
- at the front, the On/Off switch
,
• Wash or peel the fruits/vegetables that you wish
o
- to the left, the container for fruit pulp and
to process.
vegetable mash
- to the right, the outlet pipe for the juice
• Large seeds or stones should always be removed
before filling the appliance.
s
.
y
• Stone fruit (such as apples, pears) can be pro-
cessed with the skin and seed centres. Remove
all other stones (peaches, plums etc.), all large
seeds (melons etc.) and stalks to avoid possible
damage to the appliance.
• Fruits and vegetables with thick peels (e.g. citrus
fruits, melons, kiwis, beets) must always be peeled
first.
Warning:
Ensure that the appliance is switched off and the plug
removed from the wall socket before assembling the
appliance. If you do not, there is a great risk that
you could injure yourself.
- 4 -
• The main stalk is to be removed from grapes.
• Cut the fruit or vegetables into pieces that are
2. Hold the stodger
in one hand and feed the
q
fruit and vegetable pieces with the other hand
sized to fit into the loading shaft
.
into the loading shaft . ALWAYS use the stodger
w
w
• Before juicing, place the carrots in water for ab-
out 24 hours. Afterwards, guide them one after
to carefully press the fruit/vegetable pieces
q
into the loading shaft . Whilst the loaded fruit/
w
the other into the filling shaft : thereby, the
vegetables are being processed, insert further
pieces into the loading shaft. Do not switch the
appliance off.
w
thicker end of the carrot, where the leaves were,
must be facing down and the thinner root tip
must be upmost.
Note:
Note:
To avoid fruit or vegetables becoming blocked in
the loading shaft , only fill it when the appliance
is switched on. Should fruit or vegetable pieces be-
Raisins are not suitable for juicing as they contain
too little juice. Rhubarb or other fibrous vegetables/
fruits are not suitable for juicing as the fibres block
the juice extractor.
w
come stuck in the loading shaft
and they cannot
w
be promptly freed with the stodger , proceed as
q
follows to avoid damage to the appliance:
Juicing
• Immediately switch the appliance off and remove
the power plug
from the wall socket.
i
• Loosen the clasps
and remove the housing
r
Warning:
lid
.
e
DO NOT operate the juice extractor for longer than
30 minutes (CO-Time) without a break. After 30 mi-
nutes of continuous use allow the juice extractor to
cool down. Otherwise the appliance could be
damaged.
• Remove the fruit or vegetable pieces causing the
blockage.
• Reassemble the appliance and continue with
juice extraction.
3. Always switch the appliance off immediately
after all of the fruit/vegetables have been
processed.
Warning:
NEVER insert your hands or other objects into the
loading shaft
when working with the appliance.
w
This could lead to grave personal injuries and/or
serious damage to the appliance.
Warning:
To avoid blockage of the juice outlet and/or dama-
y
ge to the appliance, regularly clean the juice outlet
1. Switch the appliance on at the On/Off
and juice container , and always after every
y
t
switch
.
usage.
o
For fruit varieties that contain a lot of juice use
speed setting I.
For drier fruits select speed level II.
Emptying the pulp container
and the filter
You can extract juices continuously until the container
for fruit pulp and vegetable mash
full.
is completely
s
- 5 -
Warning:
Remove the plug from the power source when
Warning:
To avoid receiving an electrical shock, NEVER
emptying the filter . This prevents an unintended
submerse the motor/appliance base in water
d
u
starting of the motor.
or other fluids.
When the extracted juices suddenly become thicker,
or when you hear that the motor is running slower,
• Switch the appliance off at the On/Off switch
.
o
the filter must be emptied. When you have removed
the fruit pulp/vegetable mash, reassemble the
appliance.
• Soiling or overflowing fruit juices should be cleared
away immediately, as fruit stains are difficult to
remove later.
d
• For cleaning the appliance housing and the power
cable, use a cloth that is only lightly moistened.
Disassembly of the juice extractor
• Clean the stodger , the separate juice collector
q
, the housing lid and the container for fruit
h
e
If you wish to disassemble the juice extractor, e.g.
to clean it, proceed as follows:
pulp and vegetable mash in warm soapy water
and then carefully rinse them off.
s
1. Remove the power plug from the wall socket
.
i
2. Open the clasps
.
The stodger , the juice container , the housing
r
q
t
3. Remove the housing lid with the stodger
.
lid , the separate juice collector
and the con-
e
q
e
h
4. Carefully lift up the juice container . With this,
tainer for fruit pulp and vegetable mash
are sui-
t
s
the filter
releases itself from the drive shaft
.
f
table for cleaning in a dishwasher and can be cle-
d
You can now take the filter
out of the juice
aned there. To clean the filter , use the supplied
d
d
container
.
nylon brush
:
g
t
• Turn the lid of the stodger until the arrow points
q
Cleaning and Care
to the opened lock
can now remove it.
on the stodger shaft. You
The nylon brush
is inside the stodger . To
g
q
Warning:
re-close the lid, place it on the stodger so that
ALWAYS remove the power plug from the wall socket
before removing or installing accessories and before
cleaning the appliance. To avoid blockage of the
juice outlet and/or damage to the appliance, all
appliance and ancillary parts must be regularly,
and after every use, cleaned free of fruit pulp and
vegetable mash.
the arrow points to the opened lock
.
Then turn it until the arrow points at the closed
lock . The lid now sits firmly.
• Hold the filter
(with the underside upwards)
d
under running water and clean it with the nylon
brush
.
g
Colouring:
Note:
• Some fruits or vegetables could permanently dis-
colour parts of the juice extractor. This is not da-
maging and does not impair the appliance in its
functions.
DO NOT use any aggressive cleaning agents to clean
the juice extractor. The appliance and its ancillaries
may not be cleaned in boiling water.
- 6 -
Storage
The warranty period will not be extended by repairs
made under warranty. This applies also to replaced
and repaired parts. Any damage and defects extant
on purchase must be reported immediately after un-
packing the appliance, at the latest, two days after
the purchase date. Repairs made after the expira-
tion of the warranty period are subject to payment.
If you do not intend to use the juice extractor for an
extended period, wrap the cable around the cable
rewind
on the underside of the appliance.
a
Disposal
DES UK LTD
Do not dispose of the appliance in your
Tel.: 0871 5000 700 (£ 0.10 / minute)
e-mail: [email protected]
normal domestic waste. This appliance
is subject to the European Guidelines
2002/96/EC.
Kompernass Service Ireland
Tel: 1850 930 412 (0,082 EUR/Min.)
Standard call rates apply. Mobile operators may vary.
e-mail: [email protected]
Dispose of the appliance through an approved dis-
posal centre or at your community waste facility.
Observe the currently applicable regulations. In
case of doubt, please contact your local waste
disposal centre.
Importer
Dispose of all packaging materials in an
environmentally friendly manner.
KOMPERNASS GMBH
BURGSTRASSE 21
44867 BOCHUM, GERMANY
Warranty and Service
The warranty for this appliance is for 3 years from
the date of purchase. The appliance has been ma-
nufactured with care and meticulously examined be-
fore delivery. Please retain your receipt as proof of
purchase. In the event of a warranty claim, please
make contact by telephone with our Service Depart-
ment. Only in this way can a post-free despatch for
your goods be assured.
The warranty covers only claims for material and
maufacturing defects, but not for transport damage,
for wearing parts or for damage to fragile compo-
nents, e.g. buttons or batteries. This product is for
private use only and is not intended for commercial
use. The warranty is void in the case of abusive and
improper handling, use of force and internal tampe-
ring not carried out by our authorized service
branch. Your statutory rights are not restricted in
any way by this warranty.
- 7 -
Troubleshooting
Problem
Possible Causes
Possible solutions
• Connect the appliance to
a power socket.
• The power plug iis not
connected.
• The appliance is not switched • Switch the appliance on with
The appliance does not function.
on.
the On/Off switch o.
• The clasps rare not secured. • Secure the clasps r.
• Immediately switch the appliance
The motor stays still while juicing
or it turns noticeably slow or un-
regularly.
off and disconnect the power
plug i. Eliminate the blockage
(see chapter "Juicing").
• The filter dis blocked.
• You are working too fast.
• Work a little slower.
The vegetable mash is moist and
you obtain too little juice.
• Clean the filter d(see chapter
"Cleaning and Care").
• The filter dis blocked.
• You are working too fast.
• Work a little slower.
• Clean the filter dand the juice
container t(see chapter
"Cleaning and Care").
• The filter dor the juice outlet
tis blocked.
The juice wells out between the
edge of the housing lid eand
the juice container t.
• The wrong speed setting has • Select speed setting I at the
been selected.
On/Off switch
.
o
• Work a little slower.
• You are working too fast.
• Do not press so hard with the
stodger qwhen inserting more
product.
The juice sprays from the juice
outlet y.
• The wrong speed setting has • Select speed setting I at the
been selected.
On/Off switch
.
o
• Clean the filter dand the juice
outlet y(see chapter "Cleaning
and Care").
• The filter dor the juice outlet
yis blocked.
During the processing juice runs
down from the appliance base u.
• The wrong speed setting has • Select speed setting I at the
been selected. On/Off switch
.
o
- 8 -
|